| 393.47(e) |
Brake Out of Adjustment - Roto, Clamp (Short & Long), DD-3, or Bolt |
47 |
0 |
4 |
| 393.75A3-TAOL |
Tires - All others, leaking or inflation less than 50% of the maximum inflation pressure on tire not equipped with ATIS |
37 |
37 |
8 |
| 393.55E-B |
Air Brake - ABS malfunction lamp defective on trailers manufactured on or after March 1, 1998 |
34 |
0 |
4 |
| 393.53B-B |
Air Brake - CMV manufactured on or after 10/20/1994 has an automatic airbrake adjustment system that fails to compensate for wear |
25 |
0 |
4 |
| 396.3(a)1BOS |
Brake - Defective brake(s) are equal to or greater than 20% of the service brakes on the vehicle/combination |
25 |
25 |
0 |
| 393.45B2-B-AIR |
Air Brake - Hose/tubing damaged or not secured |
21 |
2 |
4 |
| 393.45B2-BHTD |
Air Brake - Hose/tubing damage into the outer reinforcement ply. |
20 |
16 |
4 |
| 393.75(a)(3) |
Tire-flat and/or audible air leak |
19 |
19 |
8 |
| 393.95A4-EEUS |
Emergency Equipment - Fire Extinguishers - unsecured |
18 |
0 |
2 |
| 392.2-SLLMF |
State/Local Laws - Wheel (mud) flaps missing or defective |
15 |
0 |
1 |
| 393.75A3-TAOLTIS |
Tires - All others, leaking in tread area and inflation less than 50% of the maximum inflation pressure on tire equipped with ATIS |
13 |
13 |
8 |
| 396.17C-PI |
Operating a CMV without documentation of a periodic inspection |
11 |
0 |
4 |
| 393.45D-B |
Air Brake - Audible air leak at a proper connection |
10 |
0 |
4 |
| 393.55(e) |
No or Defective ABS Malfunction Indicator Lamp for trailer manufactured after 03/01/1998 |
9 |
0 |
4 |
| 393.78A-WS |
Washers - Inoperative washing system. |
9 |
0 |
1 |
| 393.9A-LSML |
Lighting - Side marker lamp(s) inoperative |
9 |
0 |
2 |
| 396.5B-HWSL |
Hubs - Wheel seal leaking |
9 |
2 |
2 |
| 396.5B-L |
Lubrication - Oil or grease leak |
9 |
0 |
3 |
| 393.11A1-CSLRR |
Conspicuity Systems - Truck tractor, lower rear retro reflective sheeting missing on vehicle manufactured on or after July 1, 1997 |
8 |
0 |
3 |
| 393.30-B |
Battery - Not protected |
8 |
0 |
3 |
| 393.53(b) |
CMV manufactured after 10/19/94 has an automatic airbrake adjustment system that fails to compensate for wear |
8 |
0 |
4 |
| 393.95A1 |
Emergency Equipment - Fire Extinguishers - no fire extinguisher present or not properly rated. |
8 |
0 |
2 |
| 393.9A-LCL |
Lighting - Clearance lamp(s) inoperative |
8 |
0 |
2 |
| 393.45D-BAAL |
Air Brake - Audible air leak at other than a proper connection |
7 |
6 |
4 |
| 393.75A3-ATIS |
Tires - All others, leaking in tread area with inflation more than 50% of the maximum inflation pressure on tire equipped with ATIS |
7 |
2 |
8 |
| 393.75C-TAOTD-LT2/32 |
Tires - Less than 2/32 inch tread depth |
7 |
0 |
8 |
| 393.9A-LFTSI |
Lighting - Front - Turn signal - inoperative |
7 |
0 |
6 |
| 393.207F-SDAS |
Suspension - Deflated air suspension |
6 |
5 |
7 |
| 393.9 |
Inoperable Required Lamp |
6 |
1 |
2 |
| 393.95(a) |
No/discharged/unsecured fire extinguisher |
6 |
0 |
2 |
| 393.95(f) |
Emergency Equipment - Stopped vehicle warning devices missing or improper |
6 |
0 |
2 |
| 393.9A-LTSI |
Lighting - Turn signal - Any inoperative on the rearmost vehicle. |
6 |
6 |
6 |
| 393.9TS |
Inoperative turn signal |
6 |
2 |
6 |
| 396.3A1-ALBV |
Air Brake - Any leak from a brake valve |
6 |
0 |
4 |
| 393.207A-SAPPAS |
Suspension - Axle positioning part cracked/broken/loose/missing resulting in axle shift |
5 |
5 |
7 |
| 393.45B2UV |
Brake Hose or Tubing Chafing and/or Kinking Under Vehicle |
5 |
1 |
4 |
| 393.48A-BIBD |
Drum Brake - Inoperative other than a steering axle |
5 |
0 |
4 |
| 393.55D2-B |
Air Brake - ABS malfunction lamp defective on truck-tractor manufactured on or after March 1, 2001 for towed vehicle. |
5 |
0 |
4 |
| 393.75(a) |
Flat tire or fabric exposed |
5 |
5 |
8 |
| 393.9A-LBL |
Lighting - Backup lamp inoperative |
5 |
0 |
6 |
| 396.3A1-BALAC |
Brake - Audible air leak from a brake chamber |
5 |
1 |
4 |
| 392.9A2-C |
Cargo - Vehicle components or dunnage not secured |
4 |
4 |
1 |
| 393.203C-CBP |
Cab and Body Parts - Hood not securely fastened |
4 |
0 |
2 |
| 393.203E-CBP |
Cab and Body Parts - Cab front bumper missing/not secured/protruding |
4 |
1 |
2 |
| 393.209E-SPSLA |
Steering - Power steering leaking anywhere. |
4 |
0 |
6 |
| 393.45B2PC |
Brake Hose or Tubing Chafing and/or Kinking - Connection to Power Unit |
4 |
1 |
4 |
| 393.47D2-BLTBD |
Drum Brake - Inadequate lining/pad thickness |
4 |
1 |
4 |
| 393.48A-BMBCBD |
Drum Brake - Missing/broken component(s) |
4 |
0 |
4 |
| 393.55C1-B |
Air Brake - Truck-tractor manufactured on or after March 1, 1997, not equipped with an ABS system. System does not function or indicates a fault. |
4 |
0 |
4 |
| 393.60(c) |
Windshield - Damaged or Discolored |
4 |
0 |
1 |
| 393.75(c) |
Tire-other tread depth less than 2/32 of inch measured in a major tread groove |
4 |
0 |
8 |
| 393.9A-LHLI |
Lighting - Headlamp(s) - Any inoperative |
4 |
0 |
6 |
| 393.9A-LSLIWR |
Lighting - Stop lamps - Both inoperative when required to be on |
4 |
4 |
6 |
| 396.3A1-F |
Fuel - Dripping leak. |
4 |
4 |
3 |
| 396.5-HL |
Hubs - Leaking hub |
4 |
2 |
2 |
| 392.8-D |
Driver - Failed to inspect /use emergency equipment |
3 |
0 |
2 |
| 393.11A1-CSURR |
Conspicuity Systems - Truck tractor, upper rear retro reflective sheeting missing on vehicle manufactured on or after July 1, 1997 |
3 |
0 |
3 |
| 393.11A1-LFTSM |
Lighting - Front - Turn signal - missing. |
3 |
0 |
6 |
| 393.55C2-B |
Air Brake - CMV other than truck-tractor manufactured on or after March 1, 1998 not equipped with an antilock brake system. System does not function or indicates a fault. |
3 |
0 |
4 |
| 393.75C-TAOTD-LT1/32 |
Tires - Less than 1/32 inch tread depth at 3 locations/2 adjacent tread grooves |
3 |
3 |
8 |
| 393.9A-HLLH |
Lighting - Headlamp(s) fail to operate on low and high beam |
3 |
0 |
6 |
| 393.9A-LIL |
Lighting - Identification lamp(s) inoperative |
3 |
0 |
2 |
| 393.9A-LLPL |
Lighting - License plate lamp inoperative |
3 |
0 |
2 |
| 393.9A-LSLI |
Lighting - Stop lamps - Any inoperative. |
3 |
1 |
6 |
| 396.3(a)(1) |
Inspection, repair and maintenance of parts and accessories |
3 |
0 |
2 |
| 396.3A1B |
Brakes (general) Explain: |
3 |
0 |
4 |
| 393.11A1-LCHL |
Lighting - Lamps improper color, height, location. |
2 |
0 |
6 |
| 393.11A1-LHLM |
Lighting - Headlamp(s) - Any missing |
2 |
0 |
6 |
| 393.11A1-LRLMWR |
Lighting - Tail lamp - Both lamps on rearmost vehicle missing when required to be on. |
2 |
2 |
6 |
| 393.11B-CSRIGRR |
Conspicuity Systems - Trailers, rear impact guard retro reflective sheeting inadequate on vehicle manufactured on or after December 1, 1993 |
2 |
0 |
3 |
| 393.11B-CSURR |
Conspicuity Systems - Trailers, upper rear retro reflective sheeting inadequate on vehicle manufactured on or after December 1, 1993 |
2 |
0 |
3 |
| 393.11TL |
Truck-Tractor lower rear mud flaps retroreflective sheeting / reflex reflective material requirements for vehicles manufactured after July 1997 |
2 |
0 |
3 |
| 393.19 |
Inoperative/Defective Hazard Warning Lamp |
2 |
0 |
6 |
| 393.201A-FRMC |
Frame - Cracked/loose/broken frame member affecting support of functional components |
2 |
2 |
2 |
| 393.205A-WRC |
Wheel/Rim - Rim, spoke wheel, or adapter cracked |
2 |
0 |
2 |
| 393.209D-STPAL |
Steering - Pitman arm loose on the output shaft |
2 |
2 |
6 |
| 393.45(d) |
Brake connections with leaks or constrictions |
2 |
1 |
4 |
| 393.45A-BHTBS |
Air Brake - Hose/tubing with a bulge/swelling when air pressure is applied |
2 |
2 |
4 |
| 393.45DLPC |
Brake Connections with Leaks - Connection to Power Unit |
2 |
1 |
4 |
| 393.47A-BRC |
Brake - Rotor (disc) with a crack in length of more than 75% of the friction surface or thru the rotor |
2 |
2 |
4 |
| 393.55(c)(1) |
Truck Tractor manufactured on or after March 1, 1997 not equipped with an antilock brake system |
2 |
0 |
4 |
| 393.55D1-B |
Air Brake - ABS malfunction lamp defective on truck-tractor manufactured on or after March 1, 1997 and each single unit CMV on or after 1998. |
2 |
0 |
4 |
| 393.60E |
Windshield - Obstructed |
2 |
0 |
1 |
| 393.75A1-TEPBM |
Tires - All others - Exposed ply or belt material in tread or sidewall area |
2 |
0 |
8 |
| 393.78 |
Wipers - Inoperative / missing / damaged wipers |
2 |
0 |
1 |
| 393.95A4-EENA |
Emergency Equipment - Fire Extinguishers - not readily accessible or filled |
2 |
0 |
2 |
| 393.9A-LHWS |
Lighting - Hazard warning signal(s) inoperative |
2 |
0 |
6 |
| 393.9A-LTSIR |
Lighting - Turn signal -Any inoperative on a unit that is not the rearmost unit |
2 |
0 |
6 |
| 396.17(c) |
Operating a CMV without proof of a periodic inspection |
2 |
0 |
4 |
| 396.3A1-BALR |
Air Brake - Fails air loss rate test |
2 |
2 |
4 |
| 396.5(b) |
Oil and/or grease leak |
2 |
0 |
3 |
| 396.5A-HNL |
Hubs - No visible or measurable lubricant showing in the hub |
2 |
2 |
2 |
| 396.5B-HLOW |
Hubs - oil and/or Grease Leaking from hub - outer wheel |
2 |
2 |
2 |
| 392.2SLSNC |
State/Local Laws - CMV snow chains required |
1 |
0 |
2 |
| 392.7A-D |
Driver - Failed to conduct pre-trip inspection or make use of required parts and accessories |
1 |
0 |
4 |
| 393.11A1-LTSM |
Lighting - Turn signal - Any missing on the rearmost vehicle. |
1 |
1 |
6 |
| 393.201(d) |
Frame accessories improperly attached |
1 |
0 |
2 |
| 393.201A-FRBFC |
Frame - Cracked siderail bottom flange at least 1 inch long |
1 |
1 |
2 |
| 393.201A-FRSC |
Frame - Cracked siderail web around the radius into the bottom flange |
1 |
0 |
2 |
| 393.201A-VBF |
Van/OT Trailers - Broken floor with protruding freight and sagging crossmembers |
1 |
0 |
2 |
| 393.201A-VFC |
Van/OT Trailers - Floor crossmembers, at least 3 adjacent broken/detached and sagging below |
1 |
0 |
2 |
| 393.201A-VLRB |
Van/OT Trailers - Lower rail broken with complete separation in bay area |
1 |
0 |
2 |
| 393.201B-FR |
Frame - Cab or body mounts loose/broken/missing |
1 |
1 |
2 |
| 393.201C-FR |
Frame - Bent, cut or notched other than by vehicle manufacturer |
1 |
0 |
2 |
| 393.203(c) |
Hood not securely fastened |
1 |
0 |
2 |
| 393.203B-CBP |
Cab and Body Parts - Cab/body mounts loose/broken/missing |
1 |
0 |
2 |
| 393.205(a) |
Wheel/rim cracked or broken |
1 |
1 |
2 |
| 393.205(c) |
Wheel fasteners loose and/or missing |
1 |
0 |
2 |
| 393.205A-WRBH |
Wheel/Rim - Cracks between stud holes/hand holes |
1 |
1 |
2 |
| 393.205C-WR |
Wheel/Rim - Wheel fasteners loose/missing/ineffective/broken. |
1 |
1 |
2 |
| 393.205C-WRAWFLMIB |
Wheel/Rim - Any wheel fasteners loose/missing/ineffective/broken. |
1 |
0 |
2 |
| 393.207(a) |
Axle positioning parts defective/missing |
1 |
1 |
7 |
| 393.207(b) |
Adjustable axle locking pins missing or not engaged |
1 |
0 |
7 |
| 393.207A-STBW |
Suspension - Suspension connecting rod or tracking component assembly missing the rubber bushing or the rubber bushing is worn to the extent that the component can be moved by hand along the axis of the component |
1 |
1 |
7 |
| 393.207F-SLAS |
Suspension - Leaking 3 PSI in 5 minutes |
1 |
0 |
7 |
| 393.209B-STWLOOS |
Steering - Steering wheel lash (free play) meets or exceeds OOS chart limit |
1 |
1 |
6 |
| 393.209D-STBSP |
Steering - Ball and socket joint has movement greater than 1/8 inch measured with hand pressure |
1 |
1 |
6 |
| 393.25(f) |
Stop lamp violations |
1 |
0 |
6 |
| 393.25A-L |
Lighting - Lamps (other than headlamps), not securely mounted |
1 |
0 |
6 |
| 393.30 |
Improper battery installation |
1 |
0 |
3 |
| 393.43D-B |
Brake - Missing or inoperable breakaway braking system on a trailer(s) or converter dolly |
1 |
0 |
4 |
| 393.45 |
Brake tubing and hose adequacy |
1 |
0 |
4 |
| 393.45(b)(2) |
Brake hose or tubing chafing and/or kinking |
1 |
0 |
4 |
| 393.45B2-B |
Air brake - Hose/tubing damaged or not secured |
1 |
0 |
4 |
| 393.45C-BSG |
Air Brake - Missing or inadequate Nonmetallic tubing spring guard |
1 |
0 |
4 |
| 393.47(a) |
Rotor (disc) cracked more than 75 percent of the friction surface completely through the rotor or completely through a solid rotor or completely through a structural support |
1 |
1 |
4 |
| 393.47(a) |
Inadequate brakes for safe stopping - Brake Lining condition |
1 |
1 |
4 |
| 393.47A-BCFSBD-SA |
Drum Brake - Contaminated friction surface on a steering axle |
1 |
1 |
4 |
| 393.47A-BCLMBD |
Drum Brake - Cracked/loose/missing lining/pad |
1 |
0 |
4 |
| 393.47A-BCLMBD-SA |
Drum Brake - Cracked/loose/missing lining/pad on a steering axle |
1 |
1 |
4 |
| 393.47A-BDC |
Brake - Drum has any external crack, or has any crack that opens upon brake application |
1 |
1 |
4 |
| 393.48(a) |
Inoperative/defective brakes |
1 |
0 |
4 |
| 393.48A-BMBCAD |
Air Disc Brake - Missing/broken component(s) |
1 |
0 |
4 |
| 393.51 |
No or defective brake warning device or pressure gauge |
1 |
0 |
4 |
| 393.53BMAN |
Air Brake - CMV manufactured on or after 10/20/1994 is not equipped with automatic air brake adjusters |
1 |
0 |
4 |
| 393.55(c)(2) |
CMV other than truck-tractor manufactured on or after March 1, 1998 not equipped with an antilock brake system. |
1 |
0 |
4 |
| 393.55(d)(3) |
No or Defective ABS Malfunction Indicator for towed vehicles on vehicles manufactured after February 2001 |
1 |
0 |
4 |
| 393.60EWS |
Windshield - Obstructed |
1 |
0 |
1 |
| 393.65C-FNS |
Fuel - Tank not secured. |
1 |
1 |
1 |
| 393.65F-F |
Fuel - Improper fuel line protection |
1 |
0 |
1 |
| 393.67C7V-F |
Fuel - Missing/improper filler cap |
1 |
0 |
1 |
| 393.70B1I-CDFWFMI-LT20 |
Coupling - 20% or less of the fifth wheel fasteners on either side missing/ineffective |
1 |
0 |
3 |
| 393.70B1I-CDSLI-MT25 |
Coupling - Slider latching fasteners - More than 25% ineffective on either side. |
1 |
1 |
3 |
| 393.70B2-CDKPE |
Coupling - Kingpin not properly engaged |
1 |
1 |
3 |
| 393.75A1-TAOBETA |
Tires - All others, more than one ply is exposed in the sidewall and the area exceeds 2 square inches. |
1 |
1 |
8 |
| 393.75A1-TAORETA |
Tires - All others, has more than one ply exposed in the tread area exceeding 2 square inches. |
1 |
1 |
8 |
| 393.75A1-TFBMF |
Tires - Front, belt material/casing ply showing in tread area |
1 |
1 |
8 |
| 393.75A3-TFL |
Tires - Front, leaking or inflation 50% or less than of the maximum inflation pressure |
1 |
1 |
8 |
| 393.75B-TF |
Tires - Front, less than 2/32 inch tread depth |
1 |
0 |
8 |
| 393.86A1-RIG |
Rear Impact Guards - Trailers and semitrailers manufactured on or after January 26, 1998 inadequate or missing. |
1 |
0 |
2 |
| 393.86A2-RIG |
Rear Impact Guards - Trailers and semitrailers manufactured on or after January 26, 1998 inadequate width. |
1 |
0 |
2 |
| 393.88 |
Television/video display device - Improperly located |
1 |
0 |
2 |
| 393.9(a) |
Inoperative Brake Lamps |
1 |
1 |
6 |
| 393.9A-LPL |
Lighting - Parking lamp(s) inoperative |
1 |
0 |
6 |
| 393.9A-LRLI |
Lighting - Tail lamp - Any inoperative |
1 |
1 |
6 |
| 393.9B-LLPL |
Lighting - License plate lamp obscured |
1 |
0 |
2 |
| 393.9B-LRLO |
Lighting - Tail lamp - Any obstructed. |
1 |
0 |
6 |
| 393.9H |
Inoperable head lamps |
1 |
0 |
6 |
| 393.9T |
Inoperable tail lamp |
1 |
0 |
6 |
| 396.3(a)(1) |
Brake - Leak from air chamber |
1 |
0 |
4 |
| 396.3A1-AASGMD |
More than 25% of the slider-guide/hold-down brackets are missing or disengaged. |
1 |
1 |
3 |
| 396.3A1-AASGMD-L6 |
Any of the slider-guide/hold-down brackets are missing or disengaged. |
1 |
0 |
3 |
| 396.3A1-BARS |
Air Brake - Air reservoir separated from its original attachment points or moving more than 1 inch |
1 |
0 |
4 |
| 396.3A1-BECI |
Buses - Electrical components have broken or unsecured mounting |
1 |
1 |
3 |
| 396.3A1-DLDSCBB |
Driveline/Driveshaft - Any broken or loose center bearing bracket, bracket bolts or mounting hardware |
1 |
1 |
3 |
| 396.3A1-DLDSCBBP |
Driveline/Driveshaft - More than 1/2 inch (12.7mm) vertical movement (with hand pressure only) of the shaft in the center bearing carrier. |
1 |
1 |
3 |
| 396.3A1-DLDSUJBCB |
Driveline/Driveshaft - Any missing, broken or loose universal joint bearing cap bolt, bearing strap or retainer bolt |
1 |
1 |
3 |
| 396.3A1-HCM |
Hubs - Bearing cap, plug or filler plug missing or broken |
1 |
1 |
2 |
| 396.3A1-TAOCV |
Tires - All others, in contact with a part of the vehicle |
1 |
0 |
8 |
| 396.3A1T |
Tires (general) |
1 |
0 |
8 |
| 396.5B-HWSLIW |
Hubs - Wheel seal leaking - inner wheel |
1 |
1 |
2 |
| 396.7A-UO |
Unsafe Operations - Prohibited. |
1 |
0 |
3 |
| 396.9(d)(2) |
Failure to correct defects noted on previous inspection report |
1 |
0 |
4 |